Clutch

Moderators: trixynut, Mincehead, dicky, phuk72, Jak, Kevtrx849

Post Reply
User avatar
lars
TRX-Enthusiast
Posts: 136
Joined: Wed Jun 04, 2008 10:55 pm
Location: NL utrecht

Clutch

Post by lars » Mon Mar 29, 2010 7:50 pm

Yesterday i did a few short sprints. After those sprints the clutch was almost gone. I had lot's of free play in the cable. After adjusting it and riding a few km's the clutch cable was to tight. I needed to readjust it to it's old settings!

Clutch didn't slip but sometimes it screams when you do a fast take off.

Anyone any idea what the cause is of these symptoms?

No idea how old the clutch or springs are.
Fresh oil (motul)
Image

Smithers
TRX-Enthusiast
Posts: 62
Joined: Fri Jan 15, 2010 2:06 pm
Location: Tauranga, New Zealand

Re: Clutch

Post by Smithers » Mon Mar 29, 2010 9:38 pm

Hi, after clutch abuse, ie, slipping the clutch during hard take offs, the clutch plates heat up and expand. This will give you excess cable freeplay.......after time, when the plates cool down, the freeplay should reduce to where it was prior to the abuse..........I hear that these clutches can make scarey noises if given heavy use on take off, but thats not uncommon and nothing to worry about, apparently..........reset the clutch cable so that it has freeplay of about 2mm. approx...... After riding for a while I then recheck the freeplay (while still on the move) and see if it is about the same, as it may have reduced, and adjust it, if needed, be by manipulating the adjuster at the clutch lever bracket.......hope this helps. Good luck.

User avatar
lars
TRX-Enthusiast
Posts: 136
Joined: Wed Jun 04, 2008 10:55 pm
Location: NL utrecht

Re: Clutch

Post by lars » Mon Mar 29, 2010 9:51 pm

Thanks for your reply, it sure helps!
The screaming part is a known issue, heavy springs is a solution and if I remender correct there is a modification you can do to the basket, drilling some extra holes.

And the abuse I did was pretty heavy. Fast take off, hard on the brakes 3 times.
Image

User avatar
phuk72
Site Sponsor / Administrator
Posts: 3522
Joined: Thu Jan 06, 2005 1:47 pm

Re: Clutch

Post by phuk72 » Mon Mar 29, 2010 10:13 pm

lars wrote:Thanks for your reply, it sure helps!
The screaming part is a known issue, heavy springs is a solution and if I remender correct there is a modification you can do to the basket, drilling some extra holes.

And the abuse I did was pretty heavy. Fast take off, hard on the brakes 3 times.
there is - have a search on here and if you can't find anything PM me and I'll try and dig out the info (not done it myself but ....)
Image

User avatar
lars
TRX-Enthusiast
Posts: 136
Joined: Wed Jun 04, 2008 10:55 pm
Location: NL utrecht

Re: Clutch

Post by lars » Mon Mar 29, 2010 11:13 pm

thanks for the offer, but i found it quickly

http://trx850.motomaniac.net/forum/view ... tch+basket

Image
Image

Post Reply